Audi S4

since 2000 release

Repair and operation of the car



Audi S4
- Introduction
   About this Management
   The Audi A4/S4 cars - the summary
   Identification numbers of the car
   Acquisition of spare parts
   Technology of service, tool and equipment of a workplace
   Poddomkrachivaniye and towage
   Start of the engine from the auxiliary rechargeable battery
   Automobile chemicals, oils and lubricants
   Diagnostics of malfunctions
+ Governing bodies and methods of safe operation
+ Current leaving and service
+ Engine
+ Cooling systems, heating and air conditioner
+ Power supply systems, release and decrease in toxicity of the fulfilled gases
+ Systems of electric equipment of the engine
+ Manual box of gear shifting
+ Automatic transmission
+ Coupling, power shafts and differential
+ Brake system
+ Suspension bracket and steering
+ Body
+ Onboard electric equipment


4affa92a



Poddomkrachivaniye and towage

Poddomkrachivaniye

For performance of many operations on maintenance and car repairs it needs to be lifted and established on two or four strong supports. The car, as a rule, rises by HUNDRED the elevator.

If under the car any works are performed, the car needs to be fixed reliably. Application of an onboard jack is admissible only when replacing wheels. Carrying out repair and other work under the car in this case is forbidden. It is life-threatening!
Lift only not loaded car. Establish supports under the bottom.

Points of rise and support of an automobile jack

On the lower longeron of a body there are characteristic places designating an arrangement of forward and back nests for installation of a jack (an arrow on an illustration). To each wheel there corresponds only one nest. The poddomkrachivaniye in other places is not allowed. The distance from a nest for installation of a jack to the corresponding forward wheel arch makes about 15 cm, and to back about 25 cm.

Points of rise and support of an automobile jack

Establish a jack under the lower beam and, rotating the handle, bring his lifting paw to such height that the paw was directly under vertically located longeron edge.

Level a jack so that cam capture of a lifting paw (A) covered a longeron edge, and the mobile heel (V) rested all surface against the basis.

Jack

Rotation of the handle of a jack lift the car to a separation from the earth of a faulty wheel.

Under the wheels which remained on the earth enclose wedges to exclude movement of the car. Do not rely on the parking brake. When performing some repair work the parking brake is released.

Reference points for the elevator and the garage elevator

For an exception of damages to the lower part of the car it is necessary to enclose rubber or wooden linings. It is not necessary to lift the car at all, leaning on the power unit, the case pallet, forward or back suspension brackets since it can lead to serious damages.

Points of support in front. Are on vertical strengthening of the lower beam at tag height for an onboard jack. Strengthening of the lower beam has to be in the center of a basic plate of the elevator.

Points of support in front

Points of support behind. Are on vertical strengthening of the lower beam around a stamped tag (the shooter on an illustration) for an onboard jack. Strengthening of the lower beam has to be in the center of a basic plate of the elevator.

Points of support behind

Towage

General comments

The car has to be towed only for the eyes which are specially provided for this purpose.

Requirements of "Traffic regulations" for towage have to be observed.

The towing cable has to be elastic not to damage both cars. It is necessary to use only a cable from synthetic fibers or similar elastic materials. However it is safer to use a towing bar!

It is necessary to watch constantly that there was no unacceptably big tension, and at the same time there was no considerable resistance to swing of the car.

At towage of the car on the region of the dirt road there is always a danger of demolition on a roadside.

Before trying to start the engine towage, it is necessary to use whenever possible the rechargeable battery of other car for start of the engine – address appropriate section.

Both drivers have to know the features of driving at towage stated below and to have sufficient experience. Inexperienced drivers should not be driving any, other car.

When using a towing cable the driver of the towing car has to at start-off from the place and gear shifting especially smoothly to release a coupling pedal.

The driver of the towed car has to watch that the towing cable was constantly tense.

On both cars external light devices according to "Traffic regulations" have to be switched on.

Ignition has to be included the wheel was not blocked, and it was possible to include if necessary the index of turn, a sound signal, screen wipers and windscreen washers.

The amplifier of the drive of the working brake system executes the function only at the working engine therefore at the switched-off engine it is necessary to press much stronger when braking a brake pedal.

As at the idle engine the power steering does not function, at turns it is necessary to make bigger effort for a steering wheel.

In the absence of oil in AT it is necessary to tow the car only with the hung-out driving wheels.

Models with AT and the four-wheel drive: Towage of the car with the lifted lobbies or back wheels is not allowed.

Models with RKPP and the four-wheel drive: If the car is towed with the lifted lobbies or back wheels, the speed of towage should not exceed 50 km/h, and the distance of towage should not exceed 50 km.

Models with automatic transmission

Turn a key in the switch of ignition in situation 2.

Transfer the AT selector lever to situation "N".

Maximum speed of towage: 50 km/h.

Maximum range of towage: 50 km.
Non-compliance maximum speeds or ranges of towage can lead to damage of the transmission.

On long distances or in case of damage of the transmission towage is allowed only with the hung-out driving wheels.

At towage with the lifted forward bridge or control of the parking brake at the stand for test of brakes the engine has to be switched off. Otherwise, owing to activization of brakes damage of brakes of the back bridge will happen electronic antistrange system (ESP).

Installation of a towing cable / bar

Forward towing eye

Take a towing eye from a set of the onboard tool, at the left in an aperture for a spare wheel.

Disconnect a cover (1). For this purpose press a thumb below, around a pad (2) and press fingers above a little, having released a cover (clips spring).

Screw an eye in a carving opening against the stop by hand, then insert sideways into an eye the screw-driver or a wrench for a wheel and tighten an eye.

After completion of towage put an eye in a set of the onboard tool.

Connect a cover a pad (2) below, press it from above and thus record it.

Back towing eye

Execution 1: Screw a back towing eye the same as a lobby.

Execution 2: The towing eye is welded from below under a bumper.

Emergency start of the car towage

On models with AT - it is impossible.

For an exception of damages of the catalytic converter it is not allowed to start the car at the warm engine by towage or pushing.

Previously try to start the engine by means of the rechargeable battery of other car.

Models with AT cannot be started by towage.

Models with the petrol engine can be towed for the purpose of start of the engine on distance no more than 50 m since otherwise there is a danger of damage of the catalytic converter.

Previously try to start the engine by means of the rechargeable battery of other car.

Models with AT cannot be started by towage.

Models with the petrol engine can be towed for the purpose of start of the engine on distance no more than 50 m since otherwise there is a danger of damage of the catalytic converter.

Before towage include the 2 or 3 transfer, press and hold a coupling pedal.

Include ignition.

Slowly include coupling if both cars began to move.

As soon as the engine was started, press a pedal of coupling and switch off transfer not to run into the pulling car.